{"id":116108,"date":"2026-07-18T10:58:36","date_gmt":"2026-07-18T08:58:36","guid":{"rendered":"https:\/\/www.sonnenseite.com\/?p=116108"},"modified":"2026-07-18T10:58:37","modified_gmt":"2026-07-18T08:58:37","slug":"folding-and-sun-tracking-solar-panel-system-higher-electricity-yield-and-protection-against-severe-weather-events","status":"publish","type":"post","link":"https:\/\/www.sonnenseite.com\/en\/science\/folding-and-sun-tracking-solar-panel-system-higher-electricity-yield-and-protection-against-severe-weather-events\/","title":{"rendered":"Folding and sun-tracking Solar Panel System: Higher Electricity Yield and Protection Against Severe Weather Events"},"content":{"rendered":"\n

A PV system developed at TU Graz increases energy yield through two-axis tracking of the sun\u2019s position \u2013 particularly in the mornings and evenings. It folds up in the event of a storm, hail or snow.<\/p>\n\n\n\n

Researchers led by Armin Buchroithner from the Institute of Electrical Measurement and Sensor Systems at TU Graz have developed an innovative photovoltaic system that combines significantly higher output with protection from storms, hail and snow. The system, known as FLAPTrack (Face-to-Face Lay-Down Anti-Degradation Protection), continuously aligns the PV modules both horizontally and vertically with the sun\u2019s position. At night and when a storm is approaching, the modules fold up automatically, protecting them from damage and possible shading caused by snow and dust. A demonstration system with a capacity of 1.8 kWp is currently in operation on the roof of an office building on Campus Inffeldgasse of Graz University of Technology (TU Graz).<\/p>\n\n\n\n

Patented folding mechanism<\/h4>\n\n\n
\n
\"\"<\/a>
Armin Buchroithner from the Institute of Electrical Measurement and Sensor Systems at Graz University of Technology observes the FLAPTrack PV module folding up. Image source: Lunghammer \u2013 TU Graz<\/figcaption><\/figure>\n<\/div>\n\n\n

\u201cThe system\u2019s key innovation is a patented linear actuator that fulfils two functions: it tracks the sun and folds the panels to a protective stow position,\u201d explains Armin Buchroithner. \u201cThis dual function enables us to save on installation and operating costs, thereby improving cost-effectiveness.\u201d<\/p>\n\n\n\n

Grid load reduction and up to 56 per cent additional yield<\/h4>\n\n\n\n

Due to its optimal alignment with the sun \u2013 horizontal rotation is achieved via a belt drive in a circular guide close to the ground \u2013 FLAPTrack delivers an average increase in energy yield of just under 40 per cent compared with fixed PV modules. On some days, the increase was as high as 56 per cent. \u201cHowever, the key to the system\u2019s cost-effectiveness is the additional electricity yield during off-peak hours. In the mornings and evenings, when general electricity consumption is particularly high, FLAPTrack delivers more than twice as much electricity as traditional PV systems due to its optimal tracking of the sun\u2019s position, which also helps to mitigate grid loads and avoid instabilities,\u201d says Armin Buchroithner.<\/p>\n\n\n\n

This effect is particularly pronounced during the winter months and in locations at higher latitudes due to the sun\u2019s lower position in the sky. Furthermore, the folding mechanism keeps the PV modules free of snow, which often drastically reduces the efficiency of conventional PV systems in winter.<\/p>\n\n\n\n

Protection against gusts of wind and hail damage<\/h4>\n\n\n
\n
\"\"<\/a>
Armin Buchroither (right) and Thomas Neubauer with the FLAPTrack solar module fully folded. Image source: Lunghammer \u2013 TU Graz<\/figcaption><\/figure>\n<\/div>\n\n\n

The folding mechanism reduces the surface area exposed to gusts of wind and provides protection against hail \u2013 both of which are serious threats to solar power systems and are likely to become more common as a result of climate change. \u201cDamage to silicon wafers caused by hailstones can lead to hotspots, which reduce the efficiency of the entire module due to their increased internal resistance,\u201d says Armin Buchroithner. There is no such risk with FLAPTrack. The system, which is linked to a local weather station and regional weather forecast models, folds the PV modules up face-to-face and lays them flat on the ground in the event of a storm or hail. The back sides of the modules can be protected from impact by using an inexpensive hail net.<\/p>\n\n\n\n

For a long-term test, the researchers have fitted the PV system with numerous sensors that collect data on the weather, energy yield, wear and tear, and the forces exerted by the wind. The data forms the basis for further optimising autonomous operation and reducing weight through lightweight design.<\/p>\n\n\n

Source<\/h5>\r\n\n\n\n

TU Graz | Institute of Electrical Measurement and Sensor Systems 2026<\/a><\/p>\n

Diese Meldung teilen<\/div>